Volvo VHD Wartungshandbuch PDF herunterladen (Seite 50)

Group 170 Preventive Maintenance

Check Oil Level in PTO (Power Take-Off)

Note: For further information refer to Function Group 4.

For further information concerning component speciﬁca-

tions see service information in Group 1, “Oil and Filter

Change Intervals for Volvo Components, All Models”,

Publication Number 175-001, and any appropriate ven-

dor literature.

Power Take-Off

Volvo PTO

Volvo PTOs mount directly to the transmission and do

not need separate oil ﬁll or checks. Make sure there is

extra oil ﬁlled in the transmission for the PTO volume.

CAUTION

Transmission oil heat exchanger should be installed

when using PTO continuously over 15 minutes at a

time or with a continuous power output over 55

C.W.O. (75 hp). Without heat exchanger, the oil can

overheat and cause damage to the transmission.

If the application has a pump that is installed separately

or a blower with a driveshaft connection, the driveshaft

U-joints need to be greased at every maintenance inter-

val or more often, depending on usage. Use a lithium

based grease with EP additives and of the consistency

of NLGI No. 2.

Side Engine Mounted PTO

CAUTION

During operation, the pump must always be ﬁlled with

oil. Otherwise, damage to the pump will result.

Engine mounted PTOs mount directly to the engine and

need to be checked before vehicle operation. Make sure

the pump remains ﬁlled.

1 2 ... 45 46 47 48 49 50 51 52 53 54 55 ... 103 104

Keine Kommentare

Volvo VHD Wartungshandbuch Seite 50